English
Español
Русский
日本語
Deutsch
Français
Português
Homepage
Produkte
Electric Tailgate
Audi BaoJun BMW Buick Cadillac ChangAn Chevrolet Citroen Dodge Ford Geely Glory Haval Honda Hyundai Infiniti Isuzu Jaguar Jeep Kia Land Rover Lexus Maserati Maxus Mazda Mercedes Benz MG Mitsubishi Nissan Opel Peugeot Proton Renault Roewe SGMW Skoda Ssangyong Subaru Suzuki Toyota Tesla Volkswagen Volvo XPENG PORSHCE Wuling Vinfast LYNK&CO
Foot Sensor Device
Electric Running Boards
Range Rover Rolls Royce Lamborghini Bentley Maserati Jaguar Alfa Romeo Porsche Mercedes Benz BMW Volvo Audi Infiniti Lexus Acura Volkswagen Lincoln Skoda GMC Baojun Buick Cadillac Chang'an Chevrolet Citroen Dodge Ford Toyota Peugeot Vinfast Honda Nissan Kia suzuki Haval HUMMER Renault Jeep Mazda HYUNDAI Mitsubishi Subaru SsangYong
Car Door Soft Close
Blog
About Us
About Us
Video
Production Capacity
Service
Certificate
Nachrichten
Deutsch
E-mail：info@kaimiao-group.com
Tel：+8613423189468
0
de
English Español Русский 日本語 Français Português
automatic tailagte lifter kits
zu hause > automatic tailagte lifter kits

INSTALLATION MANUAL GUIDE FOR BEGINNERS

Ansichten : 3544
Autor : KAIMIAO
Updatezeit : 2020-12-15 19:02:00
INSTALLATION MANUAL GUIDE FOR BEGINNERS
COMMON PROBLEMS AND SOLUTONS OF ELECTRIC TAILGATE
 

Most of the problems with electric tailgate lift kits are caused by improper installation and operation. The following KAIMIAO lists some common problems and solutions!!!
 
The control box (ECU) does not work:
  1. The location of the electrical appliance is incorrect or not plugged in properly.
  2. The fuse is burned out (the fuse on the electrical appliance and the fuse on the control box)
  3. The ground wire is not connected properly, causing a bad circuit.
  4. The door lock detection wire is not connected well or not connected properly.
  5. The car battery is insufficient.
  6. The control box is damaged.
 
Electric tailgate lift kit is not closed properly and the tailgate is not completely closed.
  1. The left and right brackets are installed reversely or the bracket fixing screws are not replaced with our screws.
  2. The waterproof rubber strip of the tailgate, the interior trim panel are not installed, and the electric strut connecting wire is not installed.
  3. The lock ring are not installed properly (the original car base nut of some cars can be moved, and the lock ring must be pushed to the front of the car to fix it.)
  4. Did not lower the plastic block on the tailgate.
  5. The gap and level of the original tailgate of the each car are different. You must see it clearly before installing, otherwise it may be uneven after installing the electric tailgate lift kits.
  6. If the secondary lock cannot be locked, lock the original car lock first. And then cut the buffer block on the lock hook flat (make the semicircle on the lock hook a circle),
 
When the electric suction does not work：
  1. Our "door lock detection line" (white) is not connected properly (refer to the installation instructions for details)
  2. The connection line of the electric suction box is not connected properly
  3. The fuse of the original car is broken (the original car door lock detection line did not provide the status to our control box, which caused the electric suction box to not work)
  4. The cable is stuck or the bending angle is too small (the bending angle cannot be less than 60 degrees), resulting in the cable unable to move
  5. Broken cable, broken electric suction box, broken control box
  6. The tailgate switch detection wire is not connected properly (grounded)
  7. The front button or back button is stuck
 
The strut does not work or work Intermittently：
  1. The connecting wire of the strut is not inserted properly, and the Hall wire is in poor contact
  2. Our "door lock detection line" (white) is not connected properly (refer to the installation instructions for details)
  3. The ground wire of the control box is not connected well or the power cord is not connected well
  4. Broken strut or control box
 
Electric tailgate won't open：
  1. The car is not unlocked (most cars need to be unlocked with the remote control before the tailgate can be opened, the same is true for the original car)
  2. Our "lock detection line" (grey) or "lock drive line" (yellow) is not connected properly (refer to the installation instructions for details)
  3. The original car's fuse is broken (the original car's lock detection line did not provide the status to our control box, causing the tailgate to fail to open)
  4. Control box is broken
  
The remote control cannot open and close the tailgate：
  1. CAN wire and door lock detection wire are not connected properly (refer to installation instructions for details)
  2. Our “tailgate switch detection line” (purple) is not connected properly (refer to the installation instructions for details)
  3. Bad control box, bad remote control or low battery
  4. Install one-key window or one-key start, the remote control chip has been changed
  5. CAN information has changed
 
 The front button cannot open and close the tailgate：
1.Our “tailgate switch detection line” (purple) is not connected properly (refer to the installation instructions for details)
2.The front button cable is not connected properly
3.Front button is broken
 
Back button does not work：
  1. The rear button cable is not connected properly
2.Our “tailgate switch detection line” (purple) is not connected properly (refer to the installation instructions for details)
3.Rear button is broken
 
High memory function has no effect：
  1. The height memory position of the tailgate is not in the memory range of our control box, and there is no memory function for the position below half of the highest position of the tailgate
  2. After high memory, the door needs to be closed once for initialization
 
The car will leak electricity after installing the car's electric tailgate：
  1. Verify that the tailgate is locked with the second lock, and the control box is still working when only the first lock is locked, and the control box consumes a lot of power
  2. Check whether there is leakage of other equipment in the car
  3. Check the storage capacity of the original car battery
  4. Control box is broken
 
Drop the pole：
  1. The circlip is not in place (refer to the installation instructions for details)
  2. Circlip deformation (refer to installation instructions for details)



Welcome to contact us to get more details: 
WhatsApp: +8613423189468 
Wechat: 13423189468 
E-mail: info@kaimiao-group.com 
Alibaba: kaimiao.en.alibaba.com 
Website: www.kmautospace.com
frühere :
nächste :
im zusammenhang mit der nachrichten
lesen sie mehr >>
【DS - KM448】【INSTALLATIONSANLEITUNG】【ELEKTRISCHE HECKKLAPPE】 FÜR KIA SORENTO 2021+ 【DS - KM448】【INSTALLATIONSANLEITUNG】【ELEKTRISCHE HECKKLAPPE】 FÜR KIA SORENTO 2021+
Sep .27.2024
Die Verwendung einer elektrischen Heckklappe erhöht den Komfort beim Zugriff auf den Laderaum Ihres Fahrzeugs. Machen Sie sich mit den spezifischen Bedienelementen und Funktionen Ihres Heckklappenmodells vertraut, um dessen Funktionalität zu maximieren. G
【DS - KM622】【INSTALLATIONSANLEITUNG】【ELEKTRISCHE HECKKLAPPE】 FÜR TOYOTA YARIS CROSS 2023+ 【DS - KM622】【INSTALLATIONSANLEITUNG】【ELEKTRISCHE HECKKLAPPE】 FÜR TOYOTA YARIS CROSS 2023+
Sep .23.2024
Insgesamt ist eine elektrische Heckklappe eine praktische und innovative Funktion, die die Funktionalität und den Komfort moderner Fahrzeuge verbessert und es den Benutzern erleichtert, ihre Ladung einfacher und sicherer zu handhaben.
【ELEKTRISCHES TRITTBRETT】 Das ultimative Upgrade für Ihr Fahrzeug 【ELEKTRISCHES TRITTBRETT】 Das ultimative Upgrade für Ihr Fahrzeug
Sep .19.2024
【DS-KM402】【INSTALLATIONSANLEITUNG】【ELEKTRISCHE HECKKLAPPE】 FÜR FORD KUGA / ESCAPE / PUMA 2020+ 【DS-KM402】【INSTALLATIONSANLEITUNG】【ELEKTRISCHE HECKKLAPPE】 FÜR FORD KUGA / ESCAPE / PUMA 2020+
Sep .19.2024